PRATT AND LAMBERT INC

6027 CLEVELAND, OH 44101-1027 US

Telephone: 216-566-2902

Cage: 61196

PROPYLENE GLYCOL/METHYL ETHER ACETATE SOLVENT (VAPOR

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 25.0%

OSHA PEL NONE ESTABLISHED

ACGIH TLV: 100 PPM/375 MG/CU

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5 - 15%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICA, CRYSTALLINE - CRISTOBALITE (PIGMENT)

CAS: 14464-46-1

RTECS: VV7325000

Fraction By Weight: <1.0%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.05 MG/M3 RDUST9293

TITANIUM DIOXIDE (PIGMENT)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 20%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

SILICA, AMORPHOUS HYDRATED

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: < 5%

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

SILICA, AMORPHOUS-DIATOMACEOUS EARTH (PIGMENT)

CAS: 68855-54-9

RTECS: HL8600000

Fraction By Weight: 5%

OSHA PEL 6 MG/M3; 20 MPPCF

ACGIH TLV: 10 MG/M3

TALC (PIGMENT)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 10.0%

OSHA PEL 2 MG/M3 FIBERS*

ACGIH TLV: 2 MG/M3 FIBERS*

METHYL ETHYL KETONE (SOLVENT) (SARA 313) (VAPOR PRESSURE 70

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 5.0%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

VOC 4.46 LB/GAL LESS WATER & NPRS* 535 G/L LESS WATER

RTECS: 9999999VO

VOC 11.54 LB/GAL SOLIDS 1385 G/L SOLIDS CALCULATED. WEIGHT

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:INGEST: GASTROINTESTINAL IRRIT/NAUSEA/
VOMITING. ASPIR OF MAT'L INTO LUNG MAY CAUSE CHEM PNEUMONITIS
(FATAL). INHAL: NOSE/THROAT IRRIT. HIGH CONC MAY CAUSE ACUTE CNTRL
NERV SYS DEPRESS CHARACTERIZED B Y
HEADACHES/DIZZINESS/NAUSEA/CONFUSION.EYE: SEVERE IR
Explanation of Carcinogenicity:CRYSTALLINE SILICA HAS LIMITED EVIDENCE
OF CARCINOGENICITY IN HUMANS AND SUFFICIENT EVIDENCE IN
EXPERIMENTAL ANIMALS.
Effects of Overexposure:PROGRESSIVELY DISABLING LUNG DISEASE. LIVER
DAMAGE. PERIPHERAL NEUROPATHY. PREMANENT BRAIN AND NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE CAN BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:BENIGN/MALIGNANT LUNG TUMORS.
KIDNEY, LUNG AND SPLEEN DAMAGE. EMBRYOTOXIC, FETOTOXIC AND
TERATOGENIC.

First Aid:INGEST: DO NOT INDUCE VOMITING. CALL POISON CTR/HOSP EMER
RM/DR IMMED. INHAL: REMOVE TO FRESH AIR. GIVE ARTIFICIAL RESP IF
STOPPED BREATHING. KEEP WARM/QUIET. GET MED AID IMMED. EYE: FLUSH
W/LG AMOUNT S OF WTR, LIFTING UPPER/LOWER LIDS OCCASSIONALLY FOR 1

Spill Release Procedures:EVAC AREA. ELIM ALL IGNIT SOURCES(FLAMES/HOT
SURFACES/ELECT/STATIC/FRICTIONAL SPARKS). DIKE/CONTAIN SPILL
W/INERT MAT'L(SAND/EARTH) TRANS LIQ TO COVERED METAL CNTNRS FOR
RECOVERY/DISPOSAL/ RMV W/INERT ABSORB. USE NON-SPARK TOOLS. PLACE
DIKING MAT'L**
Neutralizing Agent:N/K **IN COVERED METAL CNTNRS FOR DISPOSAL. PREVENT
CONTAMINATION OF SEWERS***

Handling and Storage Precautions:DO NOT STORE ABOVE 115F. STORE LARGE
QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
***STREAMS/GROUNDWATER W/SPILLED MATERIAL OR USED ABSORBENT.
Other Precautions:DO NOT INGEST/BREATHE SANDING DUST. CLOSE CNTNR AFTER
EACH USE. EMPTY CNTNR MUST NOT BE WASHED/RE-USED FOR ANY PURPOSE.
CNTNRS SHOULD BE GROUNDED/BONDED TO THE RECEIVING CNTNR. NEVER USE
PRESSURE TO E MPTY. DRUM IS NOT A PRESSURE VESSEL.

Respiratory Protection:APPROP PROPERLY FITTED POSITIVE PRESS AIR
SUPPLIED RESP (TC 19C NIOSH/MSHA). IF UNAVAILABLE, USE VAPOR
PARTICULATE (PAINT SPRAY) RESP. WEAR RESP FOR WHOLE TIME WHILE
MIXING/SPRAYING/UNTIL VAPORS/ MIST S ARE GONE. FOLLOW RESP MFR
DIRECT TO US
Ventilation:LOCAL EXHAUST VENT IN SUFFICIENT VOL/PATTERN TO MAINTAIN
EXPOSURE BELOW NUSIANCE DUST LIMITS/PERMISSIBLE EXPOSURE LIMITS
Protective Gloves:SOLVENT IMPERMEABLE GLOVES.
Eye Protection:SAFETY SPECTACLES.
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Supplemental Safety and Health
NOTE TO PHYSICIAN: ANY TREATMENT THAT MIGHT BE REQUIRED FOR
OVEREXPOSURE SHOULD BE DIRECTED AT THE CONTROL OF SYMPTOMS AND THE
CLINICAL CONDITIONS.

Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.

Product ID:COATING, POLYURETHANE, AIRCRAFT WHITE 37875
MSDS Date:01/01/1987
FSC:8010
NIIN:01-144-9872
Kit Part:Y
MSDS Number: BZLKS

Waste Disposal Methods:DISPOSE IN ACCORD W/FEDERAL, STATE & LOCAL LAWS/
REGULATIONS. INCINERATE ONLY IN EPA PERMITTED FACILITY. DO NOT
INCINERATE CLSD CNTNRS. USE PRECAUTION FOR DISPOSAL OF FLAMMABLE
MAT'L. CONTAMINATED ABS ORB MAY BE DISPOSED IN A HAZARDOUS WASTE
LANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.